Outlander PHEV Sub-Zero Operation Question

[PHEV07]

We'll, it's finally drop down to -20 here in Toronto. Actually, not till tomorrow (Fri) and then till the end of Sunday. We park the 2024 Outlander outside, so I'll keep it plugged in continually unless we're using it. I don't anticipate any issues, but I'll let you all, sorry, y'all know how it goes.
It didn't need plugging in at -12, but who knows?

I bought a longer charging cable from Amazon so we didn't have to back in all the time to get the cable to reach. It's a 25 footer and I mounted it low on the garage wall so it goes under the garage door without losing much length. It's a thicker cable and it appears to be charging the car a bit faster, but that's probably my imagination considering that the cable just runs a battery charger that charges the battery.
I assume a fast charger charges the battery directly.

Yes please keep us updated.

Plz take photos of the Battery Temperature. To see where on tge bar it is at -20'C

It is currently-21'C here in Winnipeg and going down to -25'C early in the morning. 5Am to 7am

I do not plan on plugging car in tonight and will see what the Battery Temperature gauge shows in the morning.

Andre

 

[tyleriv]

As an update, I've been experiencing temperatures of -20C to -8C. During this time I've kept the car outside and plugged in over night. The low power warning has been present most of these sessions < -15C. My EV driving ratio has dropped from high 90's to mid 40's and thus most of my driving has been using the ICE as a power source. Preheating of the cabin has been of no utility during these cold temperatures as the heat pump can't seem to overcome this 35C (i.e. -15C ambient to +20C target) temperature differential. Prior to the software update, even in cold weather, and as long as the battery was above the minimum temperature, I could run in EV mode and the ICE would not start. Now it appears that the ICE will start up with any cabin heating request when the ambient temperature is lower than say -10C. Perhaps the battery is still too cold to meet certain software thresholds even as the ambient temperature is warming due to its thermal mass.

When the traction battery has been fully charged, I don't see any benefit in keeping the car plugged in from the standpoint maintaining battery temperature (which makes sense).

So, it appears I own an partial PHEV vehicle during the cold months of winter.

Now, I'm given to understand that the heat pump cools the battery during the summer, so I wonder if the heat pump can warm the battery in the winter without any hardware changes? Remember, that a heat pump is bidirectional in its heating/cooling function, I'm sure the heat pump could warm the battery 20C from ambient (e.g. -40C would be warmed to -20C). In this case, even in frigid conditions, the heat pump could be activated while the car is plugged in (like cabin heating is meant to perform), some time before the use of the car in order to insure that the battery is warm enough to be both available (therefore a guaranteed capacity to start the ICE) and effective (elimination of poor charge capacity and possible battery damage). No one complains about having to plug in an ICE in frigid temperatures so keeping a PHEV plugged in and warming through its heat pump is not a big ask. So could it be a software issue to allow the heat pump to warm the battery?

 

[Gord Walden]

I got a call from my dealership for a recall notice to do a software update that is to deal with the extra cold issue on my 2023 PHEV. It took about an hour under warranty.

 

[DougF]

We'll, it's finally drop down to -20 here in Toronto. Actually, not till tomorrow (Fri) and then till the end of Sunday. We park the 2024 Outlander outside, so I'll keep it plugged in continually unless we're using it. I don't anticipate any issues, but I'll let you all, sorry, y'all know how it goes.
It didn't need plugging in at -12, but who knows?

I bought a longer charging cable from Amazon so we didn't have to back in all the time to get the cable to reach. It's a 25 footer and I mounted it low on the garage wall so it goes under the garage door without losing much length. It's a thicker cable and it appears to be charging the car a bit faster, but that's probably my imagination considering that the cable just runs a battery charger that charges the battery.
I assume a fast charger charges the battery directly.

Were you using the forecast quoting the wind chill temperature? I think the non-wind chill forecast would determine the coldest the battery would get although a low wind chill temperature will speed up the cooling. I'm in Toronto too. The Weather Network forecast I just looked at has a low of -17°C Saturday night

I wish the vehicle would display the battery temperature in digital format or make it available to a device plugged into the ODB2 port.

 

[PHEV07]

As an update, I've been experiencing temperatures of -20C to -8C. During this time I've kept the car outside and plugged in over night. The low power warning has been present most of these sessions < -15C. My EV driving ratio has dropped from high 90's to mid 40's and thus most of my driving has been using the ICE as a power source. Preheating of the cabin has been of no utility during these cold temperatures as the heat pump can't seem to overcome this 35C (i.e. -15C ambient to +20C target) temperature differential. Prior to the software update, even in cold weather, and as long as the battery was above the minimum temperature, I could run in EV mode and the ICE would not start. Now it appears that the ICE will start up with any cabin heating request when the ambient temperature is lower than say -10C. Perhaps the battery is still too cold to meet certain software thresholds even as the ambient temperature is warming due to its thermal mass.

When the traction battery has been fully charged, I don't see any benefit in keeping the car plugged in from the standpoint maintaining battery temperature (which makes sense).

So, it appears I own an partial PHEV vehicle during the cold months of winter.

Now, I'm given to understand that the heat pump cools the battery during the summer, so I wonder if the heat pump can warm the battery in the winter without any hardware changes? Remember, that a heat pump is bidirectional in its heating/cooling function, I'm sure the heat pump could warm the battery 20C from ambient (e.g. -40C would be warmed to -20C). In this case, even in frigid conditions, the heat pump could be activated while the car is plugged in (like cabin heating is meant to perform), some time before the use of the car in order to insure that the battery is warm enough to be both available (therefore a guaranteed capacity to start the ICE) and effective (elimination of poor charge capacity and possible battery damage). No one complains about having to plug in an ICE in frigid temperatures so keeping a PHEV plugged in and warming through its heat pump is not a big ask. So could it be a software issue to allow the heat pump to warm the battery?

Really sad that this Software upgrade has done nothing to improve the operation of the 2023 to 2025 Outlander PHEV

As you have noted the Heat Pump is not able to keep the Cab very warm.

I found that on my 2024, when the outside Temp is -12'C or so, the vent Air Temp barely reaches 20'C

At outside Temp of-14'C even though the Heat Pump is working it is not able to produce any heat at tge air vents higher than 6'C.

When the outside Temperature of lower than -15'C the Heat Pump no longer operates therefor it can not warm up the Drive Battery.

Even when the outside Temperature is say -10'C and there is air vent Temp of 20'C, the Drive Battery never heats up. It o ly heats up a bit when driving cause the ICE which usually runs at these temps charges the Battery and some heat produced while driving the EV Motors but not much.

If the battery is full and if it is Plugged in, the Battery does not heat up because there is no current going thru the Battry because the Batterh is fully Charged.

These cars need to be recalled an either a Battery Heater is installed in the Batterh Pack or the Battery Pack needs to be replaced with one that has a Battery Heater.

Also the Heat Pump is absolutely useless at temperatures lower than -15'C. These cars should get a PTC back for the Cab.

My 2024 operated great from April 8, 2924 till the 1st week of November but when the temperatures started dropping lower 0'C . It works best as an ICE Vehicle except that we cannot heat the Cab very well with just the Heat Pump

I plan on suffering thru this winter. Car will operate very well when it warms up but in all really I will be looking for a different vehicle for next Winter.

Probably not an Outlander PHEV because Mitsubishi has not only refused to fix this cold weather issue but has now released the 2025 with the same problem. Namely with no Battery Heater in the Battery Pack and no PTC cab Heater to take over when the Heat Pump shuts off.

As a consolation could at least have allowed us to start the ICE whenever the Temoerature drops down to the frigid zone but did they. No.

It is really quite sad that Mitsubishi has not only designed but has release a vehicle that is not suitable for cold climates
eally sad