2023 PHEV Tire Issue

[Jhelman]

Hi,
Has anyone had to replace the original tires on their 2023 PHEV? We had a flat tire today and it turns out there is a flap in the sidewall that is leaking air. The rims are a bit scraped up, but there are only 25k miles on it, so it seems like the sidewalls might have lasted longer. I've never had this issue with other vehicles that I've owned.

I was about to use the tire slime and the mini compressor to see if I could get it inflated, but I decided to use my compressor to see if I could see the leak first. I'm glad I did because I don't think the slime would have patched the hole, and didn't want to waste it. I don't think that tire places appreciate the slime either, because it makes their job a lot messier.

I’m taking it in to our the local tire place tomorrow to get all 4 replaced (since that seems to be the only thing they do with AWD).
I believe the replacement will be all weather Continentals (50k mile warranty ), but I’m not sure the model. The quote was for just over $1000 USD.

Does anyone think it’s a good idea to keep one (or more) of the other three tires? I was thinking that I could mount one on a spare rim which could be used as a backup in case something like this happens again.
Thanks for any advice,
Jon

 

[AndyInOz]

Hi Jon,

Mine is a bit older, but I had to replace the tyres at a similar mileage because the outer edges of the tyres were badly scrubbed, with deeper tread showing in the centres.

The place that sold me the new tyres (Beaurepairs) stated that the wear pattern indicated that the tyres had been under-inflated.

They put my car on the scales and recommended that I fill the tyres to 41 psi, rather than the 38 psi as specified in the user guide.

Because I'm rarely at a petrol station, I bought a compressor for home, and can report that the car is much nicer to drive at the slightly higher pressure. (The steering is lighter, and the car feels more responsive and agile.)

I'd suggest you seek advice from your tyre place and see if it is the same.

Andy

 

[Jhelman]

Thanks Andy, I’ll see what they say.
Jon

 

[michael8554]

I had to replace two front tyres some miles after the trackrod ends were replaced and the toe-in was set neg instead of pos (or vice-versa).
No ABS or Traction Control complaints.
Have you been routinely swapping the wheels back to front to back as advised in the Owner's Manual ?

 

[Jhelman]

I had to replace two front tyres some miles after the trackrod ends were replaced and the toe-in was set neg instead of pos (or vice-versa).
No ABS or Traction Control complaints.
Have you been routinely swapping the wheels back to front to back as advised in the Owner's Manual ?

I believe that the tires were rotated the two times the oil was changed.

 

[greendwarf]

I had to replace two front tyres some miles after the trackrod ends were replaced and the toe-in was set neg instead of pos (or vice-versa).
No ABS or Traction Control complaints.
Have you been routinely swapping the wheels back to front to back as advised in the Owner's Manual ?

Can't see the point -, just makes the pain harder to bear paying for all 4 at once rather than 2 at a time!

 

[yardbird]

uneven threads mean you need wheel alignment. Phev usually don't last long due to weight of the batteries. My first set of tires lasted 20 to 25k miles and I switched to Bridgestone which lasted longer.

 

[HeliNurse]

Yep, same thing, uneven wear with scalloped edges. The dealer was running our car, (it was a demo) at 28 psi! I assume because of the roads in Adelaide combined with the bilstein suspension. Anyway going to replace all 5 (we carry a spare) with Continental Cross LX Sport 235/60 R18, I'm going up a bit to give us a bit more clearance and correct the speedo.

 

[Vasgorm]

Hi Jon,

Mine is a bit older, but I had to replace the tyres at a similar mileage because the outer edges of the tyres were badly scrubbed, with deeper tread showing in the centres.

The place that sold me the new tyres (Beaurepairs) stated that the wear pattern indicated that the tyres had been under-inflated.

They put my car on the scales and recommended that I fill the tyres to 41 psi, rather than the 38 psi as specified in the user guide.

Because I'm rarely at a petrol station, I bought a compressor for home, and can report that the car is much nicer to drive at the slightly higher pressure. (The steering is lighter, and the car feels more responsive and agile.)

I'd suggest you seek advice from your tyre place and see if it is the same.

Andy

I had the same advice from Bob Jane Tyres, manufacture's recommended tyre pressures are for comfortable softer ride but will increase tyre wear on the outer edges.

 

[Jhelman]

The 4 tires ended up costing $1425 USD. They're the Continental ExtremeContact DWS06 Plus. Hopefully these will last longer than 25K miles.

​

 

[yardbird]

The 4 tires ended up costing $1425 USD. They're the Continental ExtremeContact DWS06 Plus. Hopefully these will last longer than 25K miles.

​

Way too expensive! I got 4 Bridgestone Ecopia H/L 422 plus and I still have about 6mm out of 10mm threads left after 30,000 miles! They are only $212 USD each at Costco. I got a flat tire yesterday and claimed for road hazard. Costco charged me only $92 after 60% prorated for road hazard insurance.

 

[Haenzel]

Hi,
Has anyone had to replace the original tires on their 2023 PHEV? We had a flat tire today and it turns out there is a flap in the sidewall that is leaking air. The rims are a bit scraped up, but there are only 25k miles on it, so it seems like the sidewalls might have lasted longer. I've never had this issue with other vehicles that I've owned.

I was about to use the tire slime and the mini compressor to see if I could get it inflated, but I decided to use my compressor to see if I could see the leak first. I'm glad I did because I don't think the slime would have patched the hole, and didn't want to waste it. I don't think that tire places appreciate the slime either, because it makes their job a lot messier.

I’m taking it in to our the local tire place tomorrow to get all 4 replaced (since that seems to be the only thing they do with AWD).
I believe the replacement will be all weather Continentals (50k mile warranty ), but I’m not sure the model. The quote was for just over $1000 USD.

Does anyone think it’s a good idea to keep one (or more) of the other three tires? I was thinking that I could mount one on a spare rim which could be used as a backup in case something like this happens again.
Thanks for any advice,
Jon

There is no indication that side impact has caused your problem?

 

[yardbird]

https://www.aliexpress.us/item/3256807457315391.html?spm=a2g0o.productlist.main.15.2bdd3c69vw7AXX&algo_pvid=604c13be-6d46-4c21-8761-f9909f37806b&algo_exp_id=604c13be-6d46-4c21-8761-f9909f37806b-7&pdp_npi=4@dis!USD!364.68!134.93!!!2591.90!959.00!@2103246617297111339202618edf51!12000041626875066!sea!US!123274847!X&curPageLogUid=9yOWZjEqfOHY&utparam-url=scene:search|query_from:

ExtremeContact DWS06 PLUS UHP 225/50zr18 for $134.9 shipped from USA?? too good to be true! Anyone dares to order to see if this is legit? My tires are still good for at least 20k miles with 6mm threads left or I will try.

 

[Jhelman]

There is no indication that side impact has caused your problem?

I’m sure that scraping against curbs caused the issue. Only my wife and I drive it, and neither of us knows about any major side impact to the tires. I’ve never run into this with other cars, even though they’ve been scraped on the curb many times.

 

[Rockwallrick]

I just had to replace the front drivers side tire on our 23 Outlander Phev due to an incident my Wife had. She drove over a curb which cut the sidewall and of course left her with a flat tire and NO spare! I replaced it with an Advanta HPZ-02 all season performance tire. The car currently has 18k miles on it. I am planning on saving this tire for a spare when the time comes to get a new set.

 

[ckracer76]

I continue to be impressed by the my Outlander PHEV and the decision to switch from all-season tires to all-terrain tires.

After some reluctance on my part to look past the (relatively poor) EU label score, I chose a set of General Grabber AT3 tires.

As we head into winter, here in Wales, they seem to tackle all manner of road surfaces and changing weather conditions with ease. Highly recommended.

I have no experience of other brands but many tire manufacturers offer all-terrain tires in many different sizes.

Some are winter rated, some are just M+S and some are both. All seem to offer more sidewall protection than summer tires.

I have seen two other Outlanders with all-terrain tires. One owner had fitted BF Goodrich K02 and the other owner had fitted Yokohama G015 which I may try next time.

This forum and community is multi-national with so many owners from many different countries and climates.

Has anybody else fitted all-terrain tires to their Mitsubishi Outlander?

 

[HeliNurse]

Just fitted Yoko GO15 to our car, 235/55/18, too early to give any realistic feed back but SWMBO seems happy. Original tyres on the front got scalloped from under inflation and after rotating, the rear passenger gave up on our track. Thankfully we have a full size spare and a socket with an extending handle. The jack was ok but I will be getting some chocks.